船舶燃料アラート：ジェット燃料や自動車用燃料が混合船舶燃料に使用されています。

パンデミックの影響による需要の低下で航空・自動車業界が苦境に陥っていることから、ジェット燃料や自動車燃料が船舶用燃料の混合に活用されていることは、現在広く知られているところです。

Reflecting on the destruction of demand the aviation and automobile industries have suffered in the wake of the pandemic it is widely acknowledged that jet and automotive fuels are now being utilised for blending marine fuels. A significant uptick in low flash-point irregularities resulting in ‘off-spec’ fuel are being observed in VLSFO and MGO in Singapore and in a few cases Middle East. In VLSFO, the prime indication of this new practise is a general reduction in viscosity and density.

By way of a reminder, flash-point is the lowest temperature at which fuel gives off enough vapour to form an ignitable mixture in air, near the surface of the liquid. The lower the flash point, the easier it is to ignite the fuel. SOLAS recognises this potential danger and prescribes a flash-point lower limit for marine fuel of 60°C . Anything lower is strictly not permitted. Fuel found with a lower flash point, loaded on board or otherwise, is deemed unsafe and will result in statutory non-compliance.

It is imperative that proper testing is carried out and any potential problems with the fuel notified to the bunker suppliers without delay. From our experience, bunkers found with a flash-point slightly below 60°C (57°C or higher) will often improve, as the lighter fractions evaporate naturally. In certain cases blending with another fuel batch to raise the flashpoint might be a possible solution. This decision can be taken after considering all risks such as fuel compatibility, complications of blending on-board and the statutory requirements to be followed in a blending process.

However, if none of the options are viable, the bunkers will have to be discharged ashore.

For more information on the above, please feel free to get in touch with our Director of Risk Assessment, Ansuman Ghosh, who will be happy to assist you.